如今國內外酒店餐飲業、休閑旅游業等行業的高速發展，酒店布草洗滌行業為剛性需求。下面分享下酒店布草洗滌的工序流程：

Nowadays, with the rapid development of hotel catering industry, leisure tourism and other industries at home and abroad, the hotel linen washing industry is in rigid demand. Let's share the process flow of cloth washing in the hotel:

使用的時候要對布草按顏色、面料、污漬的輕重進行分類。

When using, the cloth should be classified according to the color, fabric and stain.

把分類好的布草以洗缸容積的80%裝缸，加入中水位清洗2-3分鐘，使污垢得到溶解，先洗去部分水溶性污垢，隨水排掉。

Fill the sorted linen with 80% of the capacity of the washing tank, add the medium water level to wash for 2-3 minutes, so that the dirt can be dissolved. First, wash off some water-soluble dirt, and then drain it with water.

預洗后把水排掉，加水至中水位，加入清洗原料。根據布草狀況，調好水溫，浴衣80℃左右，床單、巾類、餐臺布草類80-85℃左右，進行加強清洗，這樣可以提高洗滌劑與污垢所產生的化學作用和速度，起到消毒和殺菌的作用。

After pre washing, drain the water, add water to the middle water level, and add the cleaning materials. According to the condition of the cloth, adjust the water temperature. The temperature of the bathrobe is about 80 ℃, and the temperature of the bed sheets, towels, and tablecloth is about 80-85 ℃. Strengthen the cleaning. This can improve the chemical action and speed of detergent and dirt, and play the role of disinfection and sterilization.

此過程是主洗去污的補充步驟，主要去除主洗步驟中不能完全去掉的色素類污垢。在這個步驟中主要使用氧化性漂白劑（氧漂粉）。因此在操作中應嚴格控制水溫在65℃～70℃，而且要控制洗液pH值在10.2～10.8，同時根據污垢類型及織物結構嚴格控制好投放量。

This process is a supplementary step to the main washing and decontamination, mainly removing pigment dirt that cannot be completely removed in the main washing step. Oxidizing bleaching agent (oxygen bleaching powder) is mainly used in this step. Therefore, during operation, the water temperature should be strictly controlled at 65 ℃~70 ℃, and the pH value of the lotion should be controlled at 10.2~10.8. At the same time, the dosage should be strictly controlled according to the dirt type and fabric structure.

主洗后把水排掉，加入高水位進行清洗，即兩遍排水，兩遍中脫直到布草上的洗滌劑清洗干凈。

After the main washing, drain the water and add it to the high water level for washing, that is, drain the water twice, and then remove it until the detergent on the cloth is cleaned.

布草漂洗后，布草上面會含有部分殘留洗滌劑，所以加入中和酸、柔順劑，洗至4-5分鐘，進行高脫，使布草在使用時更加光澤，柔順。

After the cloth is rinsed, there will be some residual detergent on the cloth, so add neutralizing acid and softener, wash for 4-5 minutes, and then carry out high dehydration to make the cloth more shiny and soft in use.

對清洗后的布草，理順分別放入采用高溫蒸汽的燙平機，進行熨燙，溫度一般在230℃左右，烘干機里面進行烘干，溫度一般在85℃左右。

The cleaned linen shall be put into a hot steam ironing machine for ironing. The temperature is generally about 230 ℃, and the dryer is used for drying. The temperature is generally about 85 ℃.

分享酒店布草洗滌的工序流程就是這樣了，還有更多注意事項就來我們網站http://www.caibozheng.cn咨詢吧！

This is how to share the process of cloth washing in the hotel. Please come to our website for more precautions http://www.caibozheng.cn Consult!